Changing the oil in a Renault Duster manual transmission contrary to the regulations

According to the maintenance regulations for Renault vehicles, transmission oil in manual transmissions and automatic transmissions does not require replacement throughout the entire life of the vehicle. But to perform a number of operations, for example, to replace the drive oil seal, it is necessary to drain the oil from the box. The need to change the oil in the box may arise due to harsh operating conditions of the vehicle or with extremely high mileage.

Manual transmission installed on Renault Duster

JR5 - 5-speed

TL8 - 6-speed

DP2 – automatic transmission 4-speed

What kind of oil is poured into a Renault Duster manual transmission?

Manual transmission TL8 (6 manual transmission) filling capacity 2.8 liters Recommended Renault oil – ELF Tranself TRJ 75W-80 or ELF Tranself NFJ 75W-80 Manual transmission JR5 (5 manual transmission) filling capacity 2.5 liters Recommended Renault oil – ELF Tranself TRJ 75W-80 or ELF Tranself NFJ 75W-80 Oil for manual transmission with quality according to APIGL-4 and viscosity according to SAE 75W-80 The transfer case and rear gearbox are filled with Renault recommended oil - ELFTranselfFE 80W-90. There is 0.55 liters in the rear gearbox, 0.38 liters in the transfer case.

How to check the oil level in a Duster manual transmission?

You need to check the level when transmission oil leaks appear. To check the level, there is a control hole on the front wall of the box housing, closed with a threaded plug. We lift the car. Remove the engine protection. We unscrew the control plug.

Renault Duster 4×2 version:

Renault Duster 4×4 version:

Use an L-shaped Torx key to check the level.

It should be level with the bottom edge of the inspection hole. If the oil level in the box is lower, then add oil recommended by the manufacturer (see above)

We check the condition of the seal on the plug and screw it into place.

How to change the oil in a Duster manual transmission?

We lift the car on a lift. To work, you will need a container to drain the oil. Special syringe for adding oil. 8 mm square wrench. Operating procedure: Remove the engine crankcase protection. We unscrew the inspection hole plug (see above) Unscrew the drain plug with a square and drain the oil.

We tighten the plug with a new gasket (torque 20 Nm)

Fill with the recommended oil to the bottom edge of the inspection hole (see above for how to check the level in a manual transmission)

Categories of products that may be of interest to you based on the article “Changing the oil in a manual transmission”:

Spare parts, maintenance

Products from the Dustershop77 range that may be of interest to you:

Replacement procedure

The repairman will need a pit (or a lift). Having gained access to the lower part of the car, you need to remove the engine protection (if equipped).

The replacement procedure is as follows:

1. Place a container under the drain hole.
2. Unscrew the plug from the hole.
3. The oil is drained.
4. When the liquid reaches the required level when adding, the drain cap must be screwed back on.
5. At the same time, it is worth changing the o-rings.

If you use a high-quality lubricant and replace it regularly, you can count on the Duster to “run” for a long time and without problems. If there are no conditions for performing this operation yourself, it should be performed at a service station. Signs of a gearbox malfunction should never be ignored.

Procedure for changing lubricant

1. To completely change the oil, you first need to drain the old fluid. The oil must be hot so that as much of it as possible can spill out, along with dirt deposits and metal shavings. To do this, you need to drive 5-10 kilometers to warm up the engine and gearbox. Then place the car on the lift
2. Prepare tools - a syringe, an 8 mm square, new oil and filters, seals, as well as a towel and rubber gloves
3. We go under the car, remove the engine crankcase protection, then unscrew the drain plug. To do this you will need a tetrahedron
4. After removing the plug, used oil will begin to flow out of the hole into a pre-prepared pan.
5. After draining the liquid, the hole is screwed in. You may need to replace the plug gasket before doing this to avoid leaks. The plug is screwed in with a wrench with a torque of 20 Nm.
6. Fill with new oil from the official manufacturer
7. Check the level with an L-shaped wrench and screw the plug back on. If the fluid level is normal, the process of changing the oil in a Renault Duster manual transmission with a 1.6-liter engine has been successfully completed.
8. You can monitor the fluid level for 2-3 weeks and add oil if necessary.

Oil selection

Before filling, you need to decide on the brand, quality and type; for this you need to look at the operating instructions or service book. You also need to take into account what type of gearbox is used in the car: 5 or 6 speed manual transmission, or automatic transmission.

According to the manufacturer's recommendation, the following oils are poured into the gearbox: TL8, TL4, Tranself, GL-4.

You can fill in something else, but it must only be a transmission one and there must be permission for use for this brand of car. Recommended lubricant for manual transmission TransELF NFJ 75W-80, for automatic transmission ELE Renaultmatic D3 SYN or ELF Tranself FE 80W-90.

The choice of oil depending on the type of gearbox.

Oil for transfer case and rear gearbox

Oil changes in the transfer case are not provided for during the warranty period. Based on experience, it is advisable to replace it every 30 thousand km. The oil used is TRANSELF UNIVERSAL FE 80W90, 1 liter volume.

For the rear gearbox, the automaker provides a replacement period every 60,000 km, or twice as often for severe conditions. The oil used is similar for the transfer case - TRANSELF UNIVERSAL FE 80W90.

Oil for rear gearbox Renault Duster 4×4

Brake fluid

The fluid is replaced every four years or after a mileage of 90,000 km. You can fill in any DOT-4 standard liquid. For a complete replacement it is better to take 1 liter. The price of such a bottle ranges from 300–600 rubles. Our examination has shown that it is simply impossible to buy bad brake fluids in a decent metropolitan store.

When replacing, it is necessary to flush the brake system circuits until clean, clear fluid flows out.

When replacing, it is necessary to flush the brake system circuits until clean, clear fluid flows out.

Renault Duster can show high reliability only with timely replacement of operating fluids. Don't be lazy to do it on time. And I also wish not to run into a fake.

• What tricks do automakers go to in order to simplify and thereby reduce the cost of car design, and how this affects the reliability of the car, read here.
• You can check the quality of fuel using a rapid test.

Photo: Renault and “Behind the wheel”

What and when to fill in Renault Duster: expert advice

When to change the oil in a Renault Duster gearbox

The oil in a manual transmission does not change as often as in an engine, but it also gets tired from loads and dirt.

30,000 km is the optimal mileage before an oil change, according to reviews from owners of well-maintained Dusters. Of course, you can change the oil less often, but there is always a danger of exposing the gearbox to increased wear. The fact is that oil wears out not only during operation, but when the car is idle. In any case, it comes into contact with air, which means that oxidation of filler materials is inevitable. Let's not forget about wear products, sediment and dirt.

This is what the oil filler plug looks like after 30 thousand of simple operation.

Drain plug after 30 thousand mileage

The oil may be as clean as the tear of a Romanian virgin, but the additive package no longer performs its functions - it does not lubricate, does not wash, and does not cool, and besides, the anti-corrosion properties are lost. All this greatly affects the life of the gearbox. That is why knowledgeable owners recommend replacing them at least once a year. Considering that the average driver drives up to 1.5-2 thousand per month, then the replacement interval per year does not seem too short.

Interesting on the topic: Hyundai Tucson N Line 2022: body kit and even more sport

Recommended oil for manual transmission

Coolant

Antifreeze must be replaced every 90 thousand kilometers or once every 4 years. Renault recommends using proprietary carboxylate antifreeze Glaceol RX Type D, produced in the form of a concentrate diluted with distilled water.

Renault branded antifreeze

For more information about choosing antifreeze for Duster, see “All about antifreeze for Renault Duster: selection, replacement, faults.”

Changing the oil in the Duster manual transmission

It is necessary to check the lubrication level in the “mechanics” every 15 thousand kilometers.

The car plant does not provide for changing the lubricant. But from time to time it becomes necessary .

For example, changing the oil in a Duster box is required if the lubricant has a different viscosity or the box is broken.

What you will need for work:

• tetrahedron by 8 . If you don’t have this in the toolbox, you can simply sharpen the M10 bolt;
• syringe for filling the transmission.

Algorithm of actions:

1. Remove the crankcase protection from the engine.

   
   Removing the crankcase protection

2. To accurately check the level of remaining lubricant and add it if necessary, you need to pull out the filler plug and place a container just in case. The plug is sealed with a special washer. If the washer is deformed, it needs to be replaced.

3. Next, you should check the lubricant level itself; it should be level with the lower edge of the filling groove.
4. Topping up is required using a syringe until the lubricant appears on the edge. It is worth considering that pouring lubricant through the breather hole is strictly prohibited.

5. Then you need to put the plug in place.
6. To change the oil, you need to loosen the drain plug, unscrew it and drain everything into a prepared container.

7. Screw in the plug and pour lubricant into the Duster manual transmission.

Replacing the cabin filter is described in detail in this text.

Replacement Regulations

The frequency of oil changes in the Renault Duster transmission depends on operating conditions. According to official data, new oil needs to be filled in after 50-60 thousand kilometers, but such regulations are valid only for countries with a favorable and stable climate. In Russia, the oil has to be changed much earlier than scheduled - for example, after 20 thousand kilometers. In any case, the fluid level must be regularly monitored.

The most popular articles on the site:

• How often should you change engine oil?
• Oil 5w30 and 5w40 what is the difference
• What oil to pour into the engine in winter and summer
• How long does it take to change the automatic transmission oil?

Carrying out a complete oil change on a Renault Duster

To completely change the transmission fluid in an automatic transmission on a Renault Duster, you will need:

• drain the used oil from the crankcase;
• remove the side cover;
• rinse the inside of the part from traces of old oil;
• replace the working fluid filter;
• replace the cover;
• Fill the crankcase with fresh lubricant.

Draining remaining old oil

To drain the liquid in the crankcase, a plug located in the lower part of the housing is used. The algorithm for removing old oil is identical to the steps for partially replacing the working substance. Then you need to wipe the stamped side crankcase cover with a dry cloth and unscrew the mounting bolts. Care should be taken when performing work, since up to 100 ml of liquid remains in the casing.

Cleaning the tray and removing chips

The DP8 gearbox used on the Renault Duster is not equipped with a pan. The crankcase consists of 2 halves connected by bolts. Access to internal components requires removal of the unit from the vehicle. To service the solenoids, a side cover (made of steel sheet) is used. After removing the casing, wipe the inside with a rag moistened with gasoline and solvent. Many people recommend replacing the side cover gasket, but practice shows that even repeated removals do not lead to leaks.

Changing filters

The transmission design includes a flat fine filter (catalog number - 8201219252), which is mounted inside the crankcase. To remove the element, you will need to dismantle and disassemble the box. As a rule, it is changed only during a major overhaul of the gearbox. It is recommended to use an original Renault filter to clean the fluid from contaminants.